Howdy, Stranger!

It looks like you're new here. If you want to get involved, click one of these buttons!





Chevrolet Malibu: Problems & Solutions

1120121123125126175

Comments

  • paopao Posts: 1,867
    parts suppliers are always under the control of GM...that was the case with my window...a small town vendor.......anyway...keep us informed
  • paopao Posts: 1,867
    bad switch..or fuze?
  • 79377937 Posts: 390
    The same engine was used on some Chevy Cavaliers and I have a Chiltons manual for that. It seems as if the job is quite straight forward and should present no difficulties. Why do you need to change the injectors? My 1998 Cavalier has done 130,000 miles with the same injectors and no problems with them to date.

    Before you work on the fuel system you must relieve the fuel pressure.

    1. Loosen fuel filler cap to relieve tank pressure. Do not tighten at this time.
    2. Start engine and let idle.
    3. Remove fuel pump relay from power distribution block in engine compartment.
    4. Let engine run until fuel supply in fuel pipes is consumed.
    5. Disconnect negative battery cable.
  • redmaxxredmaxx Posts: 627
    bad switch..or fuze?

    Who knows? It goes in in a few days so I'm going to let the dealer fix it.
  • I am not sure what state you are in but in CA the warranty does not transfer you have to cancel it and get a refund which is prorated.
    We actually came out ahead on our buyback with the new one being on sale and we had paid off enough we could pay cash and save the finance charges and get the rebate. They do reimburse the full amount you have already paid on the car minus usage fee.
    We were offered an extended warranty and one months car payment first from GM but turned it down and held out for a buyback.
  • :sick: :mad: I have a 1999 Malibu LS. For the most part, it's a good car but recently, I've had problems with the Theft system. The light starts flashing when i first try to start the car and the car will not star. I called a dealer which told me to leave the key on the on position (without starting the engine) for ten (10) minutes and the theft system will re-program itself. This works but i find myself having to do this very frequently.
    CAN ANYONE HELP !!!???
  • Puhrince,

    I had my skylight replaced in June, and waited 10 weeks for the part to arrive. Apparently, skylights are not stocked as spare parts and my service manager told me, as you were told, that one would have to be pulled from the assembly line. The issue with my skylight was not with the glass itself, but rather, a large split in one section of the rubber trim that runs around the edge of the glass.

    I hope your replacement part arrives sooner than mine did as your issue is serious.
  • Pourlemerite,

    I finally got word from GM that the part is not coming off their assembly line,but rather it comes from a supplier in Mexico..they said the part departed from Mexico on Friday.. now why they lied to me earlier i have no idea, and why the part is being shipped only now, i have no idea tooo (neither do they)..
    and the temporary cardboard cover which was coverting the skylight hole came off on the weekend..i had to get a new cover and get it retaped again..at the same time my wife has to watch out for rain
  • dtownfbdtownfb Posts: 2,915
    I'm surprised the dealer does not have a local windshield shop for such items like this. 6 weeks is a long long time for a simple glass replacement.
  • paopao Posts: 1,867
    not sure its a straight forward glass replacement with the tint etc and it is an odd shape...so probably not a standard piece a local windshield shop would carry...they would probably have to order it as well....
  • I have a 2005 Malibu Maxx in red. I just got a recall notice on the visors. Mine were broke when I did a test drive. Plastic doesn't last too long. Lets hope these new ones are much better.... :D
  • busey1busey1 Posts: 8
    YOu might not want to here this but I had this same problem and they had to replace the whole starter system. then it continued again and they found that there was a water leak in the windshield that dripped into the main computer board under the glove box. I would have them check both out.
  • My 2000 Malibu has the same problem with the rear speakers going out.

    Did you fix yours and if so how?

    Thanks for the info.
  • This past week I'm leaving work and try to start my 04 Maxx remotely . . nothing happens. I try to unlock the doors remotely . . nothing happens. By this time I'm at the car and can hear a strange whirring. Manually unlock the car and notice every light on the dash flipping on and off randomly. Turn the key in the ignition and nothing happens, no click, nothing but the light show quits. After about 5 seconds with the key in the IGN position, my normal dashboard lights come on but car still won't start. I get a jump from a co-worker and the car starts fine. I drive home, no issues. I turn off the ignition at home and try to restart the car right away with no luck, same symptoms as before (complete with light show). Called the dealer who sent a wrecker, wrecker driver says "dead battery, happens on all the remote start cars". Dealer had the car for 4 hours then called and said car was ready, only problem was the battery died and they replaced it. I understand batteries going down, but 16 months old? Dealer says they checked for parasitic drain (something sucking the battery down) and couldn't find anything. I don't see any other posts on batteries themselves, but I'm wondering if the comment about remote start wiping the battery faster is true.
  • 79377937 Posts: 390
    I'm afraid that the new Malibu's are fine cars but are having their reputation damaged by crappy electronics. The other day my clock mysteriously lost 10 minutes causing me to be late for work. Then the radio lost its presets - I am the only driver of this vehicle and use the same key fob all the time - then, the radio refused to search so I could not re program the presets. The next day everything worked normal again.

    Once when starting the car it sounded as if it was only firing on 2 cylinders - I have the 4cyl. Ecotec - this went on for at least 30 seconds. Switched off and re started and the engine was fine again. This and other random events convinces me that some computer is hanging up or is unstable. I just hope a fix is on the way because I find it very annoying. I don't know what to expect next.
  • e2helpere2helper Posts: 1,002
    What type of radio do you have? How many lines in its display 1 or 2? That is easiest way to tell or whether it has 3 or 4 buttons on each side of display. The base level radio has 1 line and 3 buttons, the uplevel radio has 2 lines of display and 4 buttons.

    The radio with Six-Disc CD changer is another radio version which also has 2 lines of display and 4 buttons although they have different functions.
  • e2helpere2helper Posts: 1,002
    If this is factory remote starter I am not aware that it causes any extra battery drain. He might have been commenting on aftermarket stuff which I am sure would cause extra battery drain since they are adding additional electronic modules to the vehicle.

    Do you know approx build date of your vehicle?
  • 79377937 Posts: 390
    My radio has 1 line of display and 3 buttons each side. It has a single disc player.
  • TSB 04-02-32-003, does indeed reduce rattles and clunks that the steering gear can generate within the steering rack.

    It also makes the steering feel lifeless and numb, and may cause it to "pulse" in the center position.

    I'll have it checked again at the 30K checkup and see if it can be backed off a little. No fun having lifeless steering.
  • e2helpere2helper Posts: 1,002
    Thx for info. If I come up with any suggestions I will post back
Sign In or Register to comment.